[flexy_breadcrumb]
TRIPLE PLAY
Floc & Friction Reducers
a.k.a., “Elephant Snot” – These water treatment polyacrylamides are used to coagulate solids that are suspended in liquids, or in the petroleum industry to assist in oil recovery. They are water-soluble. and very easy to clean. Until they damage your tank wash. Floc & FR have some baggage – the polymer swells when water is added. The more you rinse the more it swells, at times generating hundreds of extra gallons of wastewater. Then it settles in the drains and hardens, requiring expensive clean-out work. A specially designed John-Henry procedure, along with TRIPLE PLAY® pre-solve, makes for an easy time of it, and the total wash time is only 70 minutes from start to finish – and to insure the integrity of your stainless steel, our process does not contain salt, bleach, or sulfuric acid disguised as something else. For best results, see Standard Operating Procedures.
PRODUCT DESCRIPTION
TRIPLE PLAY was developed as a safe and effective polymer pre-solve for the tank washing industry. It is an emulsifiable blend of solvents and natural oils, works differently than most polymer pre-solves. Instead of causing the polymer to swell. TRIPLE PLAY encapsulates them, allowing their removal by a simple steam and hot- water flush. The solvents contained in this product are non-flammable and present little inhalation hazard. Contains nothing to damage, activate, or corrode stainless steel or other metals and it is safe to use through all types of equipment. Typical wash times are one hour and 10 minutes. SOP available upon request.
USES AND DIRECTION
Use TRIPLE PLAY for removal of all types of water treatment polymers, especially where waste water minimization is desired. Apply 5 gallons TRIPLE PLAY via presolve system, but low volume spinner is even better so as to coat entire tank uniformly. For multi-compartment tanks simply divide up the amount needed by the number of compartments, although an additional 20% may be needed for the extra bulkheads. Via rear discharge valve apply steam for 30 minutes. Close valve and remove steam line. Drop spinner into manway and apply 50 gallons hot water (usually around 30 seconds), then drain. Hot water flush again for 30 seconds. Cool tank and inspect.
Or fill out our Quick Call Request form below.
PACKAGING
275 Gallon Tote – JBC25094
55 Gallon Drum – JBC7015
Health hazard summary
Combustible liquid and vapor. Causes moderate to severe irritation to eyes on contact. Prolonged exposure may irritate skin. Mists or sprays may irritate eyes, nose, and throat. Vapors can cause nausea, dizziness, nausea, stupor, vomiting, headache, and/or irritation to nose, throat, and respiratory system. Aspiration of vomited material may damage lungs.
SPECIFICATIONS
Appearance ……………….. Clear, Amber Liquid
pH ………………………………………………………. N/A
Specific Gravity ………………………………….. 0.83
Percent Active …………………………………. 100%
Flash Point ……………………………………… 156° F
Dilution……………………… None. Use undiluted
Foam…………………………………………………. None
Hardwater Tolerance ………………………….. N/A
Ammonia…………………………………………… None
Phosphate…………………………………………. None
Storage Stability…………………………. Excellent*
* 1 year under normal conditions
Benefits
✅ Reduces Swelling
✅ Minimizes Water Usage
✅ No Salts
✅ No Acids
✅ No Bleach
✅ Does Not Promote Rust
✅ Clean Tank In 70 Minutes
Or fill out our Quick Call Request form below.